Within 30 days, it was possible to reduce the pyrite sulfur content in coal samples by 8595% and the total sulfur content by 3151%. The microorganisms were cultured on a solid nutrient medium, the process of coal desulfurization proceeded at a temperature of 30°C, the pulp density was 10%, and the coal particle size was 74 μm.
WhatsApp: +86 18203695377
The flue gas desulfurization process in coalfired power plants is energy and resourceintensive but the ecoefficiency of this process has scarcely been considered. Given the fluctuating unit load and complex desulfurization mechanism, optimizing the desulfurization system based on the traditional mechanistic model poses a great challenge. In this regard, the present study optimized the eco ...
WhatsApp: +86 18203695377
In the process of use, highsulfur coal will produce many sulfurcontaining substances, resulting in acid rain, haze and other pollution to the ecological environment (Chen et al., 2019). Coal cleaning technology has become a key link to control environmental pollution caused by coal burning (Yue et al., 2021).
WhatsApp: +86 18203695377
In this work, the desulfurization process of highsulfur anthracite coal is discussed, and the desulfurization method of "reduced iron powder + heat treatment + magnetic separation" (named "RIHM") is designed. The effects of the heating temperature, heating time and coaliron mass ratio on desulfurization were discussed, the process of ...
WhatsApp: +86 18203695377
CoalFired Boiler Flue Gas Desulfurization System Based on Slurry Waste Heat Recovery in Severe Cold Areas. Chenghu Zhang, 1 Dezhi Zou, 1, 2, * Xinpeng Huang, 1, * and Weijun Lu 1 ... In the process of mass exchange, when other factors are neglected, as the water in the slurry enters the flue gas, the reduced mass of the slurry should be equal ...
WhatsApp: +86 18203695377
The major coal desulphurization technologies prior to combustion are physical coal cleaning, chemical and biological methods. Each has some technical and economical limitations. Physical coal cleaning can only remove limited amount of inorganic sulphur due to insufficient liberation. Fine grinding can liberate fine pyrites, where novel coal ...
WhatsApp: +86 18203695377
1 INTRODUCTION. The coal is still one of the indispensable fuels in the world. In recent years, 93% of electric power is produced from coal in South Africa, 79% in China, 78% in Australia, 68% in India, and 39% in America. 1 However, a large amount of SO 2 and other sulfurcontaining gases was released into the atmosphere in the process of highsulfur coal combustion, resulting in ...
WhatsApp: +86 18203695377
The wet flue gas desulphurization has been the most widely used in the coalfired power plants because of high SO 2 removal efficiency, reliability and ... Meanwhile, the desulphurization process in the PCF device was analyzed using the twofilm theory of gasliquid masstransfer. The results show that the PCF device has low pressure drop ...
WhatsApp: +86 18203695377
The oxidation process of coal conversion is possible by microorganisms after getting influenced by the polyfunctional coal structure and this process usually ... Beyer, M., Ebner, H. G., Klein, J. (1986). Influence of pulp density and bioreactor design on microbial desulphurization of coal. Applied Microbiology and Biotechnology, 24 ...
WhatsApp: +86 18203695377
Experimental process and equipment Coal samples pretreatment process. To reduce the impact of soluble impurities in the coal sample on the microbial desulfurization effect, it is necessary to pretreat the coal sample (Chen et al., 2021; Rout et al., 2022), the steps were shown in Figure 3. Appropriate amount of coal sample was put ...
WhatsApp: +86 18203695377
This paper briefly introduces various methods of coal desulfurization (physical desulphurization, chemical desulfurization, biological desulfurization, etc.) and analyzes some problems existing in each method. The principle and research process of friction electrostatic separation technology and high gradient magnetic separation technology in precombustion desulfurization technology are ...
WhatsApp: +86 18203695377
Sulfur in coal exists in inorganic and organic forms, the former being mostly pyritic sulfur. Total sulfur contents in major coalfields are in the range of roughly wt%. In coal combustion, to generate electric power and process heat, the sulfur is emitted as SO2, which is seen as one of the main causes of acid rain. This effect has led ...
WhatsApp: +86 18203695377
A process flow diagram for the HDS plant is shown in Fig. 1. Desulfurization reactions take place in fixed bed catalytic reactors (∆ R) where a minimum ratio H 2 /hydrocarbon must be ensured for catalyst maintenance reasons. Reactors are fed with a blend of fuels of different qualities. The hydrocarbon (HC) feed is mixed with the recycled H 2 stream (R) and with makeup H 2 from the network.
WhatsApp: +86 18203695377
Coal is a nonrenewable fossil fuel and has been used as a main source of energy for centuries. Fossil fuels are utilized as not only for energy production but also the raw material as the main inputs for many industries such as paint, plastic, pharmaceutical, cosmetics, iron steel and aluminum production (Prayuenyong 2002).However, the use of coal, both the energy source of some of the major ...
WhatsApp: +86 18203695377![Process for coal desulfurization. [use of microwave energy]](/r4m1z83/395.jpg)
A process for coal desulfurization generates extremely low amounts of heat from microwave energy to induce thermochemical, insitu, reactions to liberate sulfur in the form of stable gaseous species, such as H/sub 2/S, COS and SO/sub 2/. Inventors:
WhatsApp: +86 18203695377
Desulfurization techniques process and future challenges for commercial of crude oil products: Review ... and challenges of existing HDS processes. The second part examines recent advances in desulphurization techniques and future challenges for commercial, that are being researched around the world and are regulating the manufacture of a new ...
WhatsApp: +86 18203695377
In this pretreatment process, the coal layer thickness and length of stay in the reaction cavity should be controlled, the sulphurcontaining gases within the cavity should be exported timely, and it should be ensured that the temperature of the coal sample after pretreatment was 150250 °C. ... (1996) Microwave desulphurization of coal ...
WhatsApp: +86 18203695377
During the project of the technical transformation of a 75t/h CFB boiler, the desulphurization rate, the utilization ratio of CaO, the sintered ratio of CaO, etc. can be got, by the calcium conservation and sulfur conservation according to the analysis of coal and...
WhatsApp: +86 18203695377
To reduce the risk of spontaneous combustion during coal storage and transportation, microbial desulfurization technology is used to reduce the content of inorganic sulfur in coal. A strain of Aciditithiobacillus ferrooxidans was purified from coal mine water in Datong, Shanxi Province, and its desulfurization test conditions were optimized. Taking the inorganic sulfur removal rate of coal as ...
WhatsApp: +86 18203695377
In the flue gas ammonia desulfurization process of the coal chemical industry, ammonium sulfate slurry in the desulfurization tower often s and overflows, which wastes resources and pollutes the environment. The solution to this problem remains largely unknown. This paper aims to reveal the causes of ing by analyzing composition, ammonia desulfurization process raw material source ...
WhatsApp: +86 18203695377
In this paper, a twostep desulfurization process for highsulfur coal was investigated. Two Chinese coals with the addition of 10 wt % potassium hydroxide or sodium hydroxide were pyrolyzed under an atmosphere of nitrogen or hydrogen in a fixedbed reactor at 600 °C, and then the obtained chars were washed with hot water. The results indicated that, without the addition of an alkali ...
WhatsApp: +86 18203695377
During research, desulphurization process has several coal parameters like ash%, VM% and FC% change. The variations of ash% through desulphurization process are shown in Figure 5. From Figure 5, it has been observed that the ash content of coal is growing with increase in contact time and KOH concentration. For 10% KOH solution, the ash% is ...
WhatsApp: +86 18203695377
يرغب أحد موردي المواد من بلجيكا في إنتاج مسحوق الحجر الجيري لملابسه...
الهند غنية بالموارد المعدنية المختلفة وهي سوق مهم لمعالجة المعادن
Copyright © 2023 GMC Co., Ltd. SiteMap
